Sita Air Flight 601

Sita Air Flight 601 (ST601) was a Nepalese domestic passenger flight, operated by Sita Air from Tribhuvan International Airport in Nepal's capital Kathmandu to Tenzing-Hillary Airport in Lukla. On 28 September 2012, the Dornier 228 serving the route crashed while attempting an emergency landing at Kathmandu shortly after takeoff, killing all 19 people on board.

Sita Air Flight 601
The wreckage of Flight 601 minutes after the crash
Accident
Date28 September 2012 (2012-09-28)
SummaryLoss of power on take-off for undetermined reasons
SiteMadhyapur Thimi, Nepal
27°40′50″N 85°21′22″E
Aircraft
Aircraft typeDornier 228
OperatorSita Air
Registration9N-AHA
Flight originTribhuvan International Airport, Kathmandu, Nepal
DestinationTenzing-Hillary Airport, Lukla, Nepal
Occupants19
Passengers16
Crew3
Fatalities19
Survivors0

The final report, published by the Nepal's Aircraft Accident Investigation Commission (NAICC), determined that a thrust reduction occurred during the take-off roll, but the cause of the anomaly could not be determined. Subsequent crew inability to maintain speed above stall speed, followed by the insufficient height of the aircraft, led to the aircraft crashing.

Accident

Flight 601 took off from Tribhuvan International Airport at 06:17 local time. It was the first flight to depart from Tribhuvan International Airport that day. While at an altitude of 50 feet (15 m), the pilot reported technical issues with the aircraft, and requested to fly back to the airport.[1] Flight crews reported to Kathmandu that the aircraft[2][3] may have hit a vulture.[4] This was noticed by Kathmandu's air traffic controller, as the aircraft began to sway and do unusual manoeuvres. Three minutes after take-off, on the way back to the airport, the aircraft descended near Manohara River. It then nose-dived, narrowly missed a slum and crashed on the banks of the Manohara River and caught fire. The front part of the fuselage was completely destroyed.[1]

Immediately after the crash, Tribhuvan Airport's fire brigade were quickly deployed. Dozens of army personnel and rescue personnel rushed to the scene of the crash, though some reports said the fire brigade took more than half-an hour. Eyewitnesses stated that several people survived the crash and were screaming for help inside the burning wreckage. Local residents wanted to help, but were afraid that if they directed water onto the engine it might explode. When emergency services arrived at the crash site, most parts of the plane were completely destroyed. All 19 people on board perished in the accident.[4]

Aircraft
9N-AHA at Lukla Airport in 2011

The aircraft involved in the accident was a twin turboprop Dornier 228-202, registration 9N-AHA, serial number 8123. Before it was sold to Sita Air,[5] it was acquired by Holiday Express in 1987. It later entered the Australian registration of VH-NSH and then the American registration of N2255E for G M Hock Construction. It was sold to Executive World Airways as F-ODZG and in 1990 it was sold to Air Caraïbes.[6]

Passengers and crew

Most of the passengers were foreigners, travelling to Lukla for trekking in the Himalaya. The British Embassy in Nepal confirmed that at least 7 Britons were on the flight. The youngest British victim was 27 whilst the oldest was 60. At least 5 Chinese nationals and 7 Nepalis were on board the flight.[7][8][9][10][11]

Nationality Fatalities Total
Passengers Crew
Nepal 4 3 7
China 5 0 5
United Kingdom 7 0 7
Total 16 3 19

Investigation

The Nepal Civil Aviation Authority was ordered to investigate the crash with assistance from the British Air Accidents Investigation Branch. Investigators started to collect evidences related to the crash. Both the flight data recorder and the cockpit voice recorder were recovered. During its takeoff roll, the weather in Tribhuvan was in good condition with good visibility. Based on interviews by eyewitnesses, the aircraft was on fire while it was crashing to the ground.[1]

A relative of Flight 601's co-pilot said he had warned that flights on the airline were routinely overloaded and that a nearby slum attracted birds to the runway. However, Sagar Acharya, the airline's head of flight safety, denied the aircraft was carrying too much weight. Most reports stated that the aircraft suffered a bird strike shortly after taking off from Tribhuvan. Conflicting reports stated that it had struck a black eagle, while others stated that it had hit a vulture. This bird strike report was confirmed by the air traffic controller on duty, as the air traffic controller stated that the pilot contacted Tribhuvan's Tower for an intention for emergency landing due to "technical glitches", possibly due to a bird strike. Based on the ATC statements, the right engine of Flight 601 might have been hit by a bird and caught fire. Investigators later focused on the bird strike theory.[1]

Investigators later stated that the impact of the bird strike might have caused the pilot to become nervous. The aircraft later caught fire, and in an attempt to douse the fire, the pilot attempted an emergency landing on Manohara river, but somehow nose-dived and crashed onto the football ground.[12]

Based on preliminary report published on 30 September 2012, the bird collided with the right hand engine at about 50 feet above ground causing some part to separate from the engine. The part later impacted the vertical tail and disabled the rudder, severing the controls of the plane. The plane then began to turn sharply. It then went out of control and subsequently crashed.

Investigators inspected the CCTV footage of the crash, and noticed that a flash had occurred on the right engine of Flight 601, approximately 5 seconds before rotation. An eyewitness, a professional pilot, reported that he noticed that the aircraft had an unsuccessful attempt to lift the aircraft. The nose did lift up however with the tail of the plane nearly struck the ground. The NAAIC then found that the crew called "V1" prematurely, thus the aircraft couldn't get airborne. The NAAIC then reported that the aircraft was not able to maintain 77 KIAS in level flight suggesting that one engine had failed and the other had suffered a power loss of at least 13%.[13] An analysis later was made by the NAAIC:[14]

"It is possible that the bird momentarily disturbed the air flow into the engine before it was struck by the propeller, causing a surge and the suspected flame seen in the CCTV footage, but the engine manufacturer considered this unlikely. The manufacturer considered that if the bird had been sufficiently close to the air intake to disturb the air flow it would have been sucked in. If the flame seen in the CCTV and accompanying 'bang' heard on the CVR were evidence of an engine surge, then another possible cause is a fuel flow problem. However, the manufacturer also commented that this type of engine was very resistant to surge."

Later investigation found that the propellers of Flight 601 were not on feathered position and were operating normally. The investigation revealed that the engine had not lost all power but was operating at low power. Thrust levers in the cockpit was also revealed that there were no engines that had been shut down by the crew during the incident. No bird remains were found inside the engines. However, there was evidence that the black kite had been struck by the propellers.[13]

According to the load sheet of Flight 601, the flight took off with a takeoff mass of 5,834 kg and an estimated landing mass of 5,698 kg. The load sheet indicated that no luggage had been loaded, surveillance videos however showed luggage of about 80 kg was loaded and not removed before the aircraft departed the stand. Thus the takeoff weight was corrected to 5,914 kg while using Nepal's standard weights for passengers, thus the aircraft was overloaded. However, overloading alone can not explain the performance problem, as further analysis revealed that a grossly overloaded aircraft would have had a better performance than 9N-AHA during the accident flight.[13]

Sound analysis of the cockpit voice recorder and flight data recordings revealed that the drag produced by the propeller exceeded the thrust produced. The investigation later stated: "The drag on an engine at flight idle is greater than the drag on an inoperative engine (OEI), and in the case of 9N-AHA where the flight idle fuel flow was incorrectly set too low, the drag would have been even greater at idle (in excess of 350 lb of drag – reference section 1.16.2). It is therefore possible that at about 6,200 kg with one engine at 100% power and one engine at flight idle, there would have been insufficient thrust to maintain 77 kt, and the additional drag on one side would have affected controllability more than in the OEI case"[13]

Investigators stated that the power loss occurred at 70 KIAS, while V1 was at 83 KIAS. When a power loss occurred below V1, the crew should have rejected the take off. The crew seemed to not be aware of the power loss. The aircraft continued to accelerate, though at a lower rate than during previous takeoffs, became airborne at 86 KIAS above V2 and continued to accelerate for about 2 seconds, at which point the speed began to continuously decay. NAAIC stated that the crew possibly didn't recognize the power loss because it occurred gradually and progressively rather than instantaneously.[13]

If an aircraft malfunction occurred on takeoff or above V1, the airport allows flight crews to continue the takeoff or land back on the runway should it be long enough to safely bring the aircraft to a stop. A long runway was available during the incident, which should have been sufficient to bring the aircraft to a halt. However, the crew opted to not choose this option and continued their flight. The investigation stated that the crew were likely opted not to land back to the airport because of company policy to continue their flight for an engine malfunction at or above V1.[13]

The NAAIC then concluded its investigation as follows:[14]

"No faults were found with either of the engines, there was no evidence of a bird ingestion into the engine. Both engines were producing low power at impact, both propellers were in their normal operating range. However, an insidious power reduction occurred starting at 70 KIAS which went unnoticed by the crew. Following lift off the pitch attitude was set too high for the aircraft to maintain V2, the aircraft's speed fell below V2 requiring more thrust than available to accelerate again. The investigation was unable to determine the cause of the thrust reduction."

See also

Notes and references
  1. Toh, Mavis (28 September 2012). "Sita Air Do-228-200 crash kills 19 in Nepal". Flightglobal. Archived from the original on 29 September 2012. Retrieved 1 October 2012.
  2. Alleyne, Richard (1 October 2012). "Nepal plane crash pilot had safety concerns". The Telegraph. Archived from the original on 1 October 2012. Retrieved 1 October 2012.
  3. Buncombe, Andrew; Taylor, Jerome (28 September 2012). "City lawyer among seven Britons killed in Nepal plane crash". The Independent. Archived from the original on 1 October 2012. Retrieved 1 October 2012.
  4. Moores, Victoria (28 September 2012). "19 killed in Sita Air Dornier 228 crash". Air Transport World. Archived from the original on 29 September 2012. Retrieved 1 October 2012.
  5. Accident description for 9N-AHA at the Aviation Safety Network. Retrieved on 28 December 2012.
  6. "REGISTRATION DETAILS FOR 9N-AHA (SITA AIR) DORNIER 228-202".
  7. Samiksha, Koirala (29 September 2012). "All 19 on board die in Sita Air crash". República. Archived from the original on 1 October 2012. Retrieved 1 October 2012.
  8. Shengnan, Zhao; Yunbi, Zhang (29 September 2012). "19 killed as plane crashes in Nepal". China Daily. Archived from the original on 1 October 2012. Retrieved 1 October 2012.
  9. Shrestha, Manesh (28 December 2012). "19 dead in crash of plane carrying tourists to Everest staging post". CNN. Archived from the original on 29 December 2012. Retrieved 28 December 2012.
  10. Sharma, Gopal (28 September 2012). "British, Chinese among 19 dead in Nepal plane crash". Kathmandu: Reuters. Archived from the original on 28 December 2012. Retrieved 28 December 2012.
  11. "Nepal plane crash: Seven Britons among 19 dead". BBC News. 28 September 2012. Archived from the original on 1 October 2012. Retrieved 28 December 2012.
  12. "Nepal plane crash: seven Britons killed after bird hit engine".
  13. Hradecky, Simon. "Crash: Sita D228 at Kathmandu on Sep 28th 2012, bird strike". The Aviation Herald.
  14. "Sita Air Pvt. Ltd., Nepal, Aircraft (9N-AHA, DO-228), 28th September, 2012, at 420 m south-east of the threshold of Runway 02 of Tribhuvan International Airport, Kathmandu, Nepal" (PDF). Aircraft Accident Investigation Commission, Civil Aviation Authority of Nepal. 26 August 2013. Retrieved 4 November 2020.
This article is issued from Wikipedia. The text is licensed under Creative Commons - Attribution - Sharealike. Additional terms may apply for the media files.